Thread: Sanya SR125 carb problems...
Results 1 to 1 of 1
|
-
#1 Sanya SR125 carb problems...
- Join Date
- Apr 2012
- Location
- chester
- Posts
- 1
04-22-2012, 07:04 PMAdvice happily received! I am currently helping a friend who is getting into biking on a budget! He has been offered a Sanya SR125 for £200. Its been stood up for 4 years (its only 5 years old!!!!) and has only done 1800 miles. It was a non runner but we agreed with the owner a £50 deposit to allow us to take it away and see if we could get it to run. So after a few hours of playing it starts, runs, all key electrics work (starter motor and indicators need investigating) but after giving the carb a really good clean (including all jets out) and new fuel, it is still bogging down when rolling on from idle to 1/2 revs quickly. A gradual increase allows it to rev cleanly and at all points on the rev range it runs really nice. Interestingly if the choke is in 1/2 open it will rev through OK. The key points to note are as follows:
Changing the mixture screw position does not really alter the problem
Above 1/2 revs the bike will pick up on a rapid throttle open clean, the problem is only from idle to 1/2
The carb - this is where it gets interesting! The slow idle jet in the float bowl and the air screw are off set by about 7 mm although in the main throttle body their are two air holes, one directly above the jet and one above the mixture screw. If you put a piece of fine wire up through the jet housing it appears to hit a "step" and if you hold it to the light you can not see anything BUT of you blow a high pressure air line thought it BOTH holes in the main carb body exert air 9and I also filled it with duck oil as a tracer and this came out of both holes)
My immediate impression is that the hole above the jet is still blocked due to the presence of no light and a piece of fine wire not passing through
Would appreciate other peoples thoughts ?
Carb is marked as a Dekni Pz26 YB40NE18
Rob
« Previous Thread | Next Thread » |
Similar Threads
-
problems
By ghost77 in forum Dirt n' Dual-SportReplies: 5Last Post: 02-02-2012, 04:08 AM -
Sanya, Hainan - rented bike
By felix in forum Ride Reports and MeetingsReplies: 4Last Post: 03-12-2010, 04:46 AM -
ajs dd125e carb settup single carb chengway and increase speed
By biker paul in forum Modifications (Cosmetic and Performance)Replies: 1Last Post: 02-21-2010, 02:57 PM -
Lhasa - Sanya and duty
By flyingtiger in forum Ride Prep and Making TracksReplies: 4Last Post: 11-22-2009, 01:25 AM -
Different Carb On QM200GY?
By firefightermatt in forum Modifications (Cosmetic and Performance)Replies: 6Last Post: 04-20-2009, 02:29 PM
MedSolutions: Finding Solutions to...
Today, 08:28 AM in Off Topic Discussions