Results 1 to 10 of 10
|
-
#1 CF650nk Dies while driving or misfires but starts after that normal
- Join Date
- Jun 2013
- Location
- Hanoi, Vietnam
- Posts
- 182
08-02-2013, 08:09 AMSo problem is this. Bike starts good and idle good, driving a while it might start to backfire and refuse to rev without backfiring and lunging forward (loosing power and then suddenly getting power) some times EFI error light comes on with one long and 2 short flashes = ERROR_INJ1(1cylinder injector)_SCG = S.C.G = Short Circuit to Ground.
If i keep rev's high it don't backfire (above 5000rpm) and runs... well fast :)
Today i also notice first time ever that idle went up and down for a while.
never notice this symptom before.
but odd thing is that if it start to do that i just hit kill switch (while driving even) let it roll a bit then hit start and problem goes away?? and bike runs good again.
at least for while, sometimes full day.
second symptom is similar but instead of backfiring while driving it started to die suddenly. just pull clutch and it dies, again starting the bike there is no sign of problems!!
I first thought it was dirty fuel so i did empty gas tank and filled it up fresh fuel. still same thing.. (did not clean filter thinking it would replace bad with good later... )
when i removed tank i notice that after i removed fuel line from fuelpump it was still leaking gasoline.
Is this normal??
When i removed tank on my Yamaha FZ1 it did not let fuel out at all.
-
#2 Re: CF650nk Dies while driving or misfires but starts after that normal
- Join Date
- Jun 2013
- Location
- Hanoi, Vietnam
- Posts
- 182
08-03-2013, 07:14 AMUPDATE: While driving work it started to die more and more.. Fuel level was 2 bars still
decided to stop for refuel and after that it worked again and did not die at all!
Could this just be failing fuel pump? because it did idle ok but if i tried to turn throttle
it died unless i slipped clutch and raised PRM a lot.
-
#3 Re: CF650nk Dies while driving or misfires but starts after that normal08-05-2013, 03:52 AM
Could it be bad fuel? Not sure about bad fuel in Vietnam but in China it could cause the problems you're talking about.
-
#4 Re: CF650nk Dies while driving or misfires but starts after that normal
- Join Date
- Dec 2010
- Location
- Southampton, UK
- Posts
- 101
08-05-2013, 05:32 PMPossibly a vacuum issue, next time it dies just open the fuel cap to see if you've got a vacuum forming in the tank, if so check to make sure none of the breather pipes from the tank are kinked or pinched...
-
#5 Re: CF650nk Dies while driving or misfires but starts after that normal
- Join Date
- Jun 2013
- Location
- Hanoi, Vietnam
- Posts
- 182
08-07-2013, 01:32 PM
-
#6 Re: CF650nk Dies while driving or misfires but starts after that normal
- Join Date
- Jun 2013
- Location
- Hanoi, Vietnam
- Posts
- 182
-
#7 Re: CF650nk Dies while driving or misfires but starts after that normal08-07-2013, 03:59 PM
breather pipes never fill up with fuel they are there to draft air into the tank when the fuel is being pumped out if its kinked it'll cause a lack of air meaning the pump can still keep pumping but only a very limited amount of fuel would get through, I had a fuel starvation problem with my bike at higher speeds where the suction was strong enough it would run fine but below 8K revs it would stutter allot.
Kennon
-
#8 Re: CF650nk Dies while driving or misfires but starts after that normal
- Join Date
- Jun 2013
- Location
- Hanoi, Vietnam
- Posts
- 182
08-16-2013, 04:12 AM
-
#9 Re: CF650nk Dies while driving or misfires but starts after that normal
- Join Date
- Nov 2013
- Location
- Malaysia
- Posts
- 2
-
#10 Re: CF650nk Dies while driving or misfires but starts after that normal
- Join Date
- Jun 2013
- Location
- Hanoi, Vietnam
- Posts
- 182
« Previous Thread | Next Thread » |
Similar Threads
-
CF650nk few questions
By Wald0 in forum StreetReplies: 2Last Post: 07-02-2013, 08:22 AM -
CF650NK Arrived
By choldy in forum StreetReplies: 8Last Post: 06-23-2013, 06:33 PM -
TumToe is here; please continue on as normal...
By TumToe in forum Welcome to MCM!Replies: 15Last Post: 09-24-2011, 06:11 PM -
Beer Girl starts the QM200 in HD
By Serpentza in forum Dirt n' Dual-SportReplies: 7Last Post: 03-02-2011, 03:59 AM -
Kick starts ?
By Sprocket in forum Modifications (Cosmetic and Performance)Replies: 5Last Post: 04-02-2010, 02:01 PM